지원사업
학술연구/단체지원/교육 등 연구자 활동을 지속하도록 DBpia가 지원하고 있어요.
커뮤니티
연구자들이 자신의 연구와 전문성을 널리 알리고, 새로운 협력의 기회를 만들 수 있는 네트워킹 공간이에요.
논문 기본 정보
- 자료유형
- 학술저널
- 저자정보
- 저널정보
- 대한기계학회 Journal of Mechanical Science and Technology Journal of Mechanical Science and Technology Vol.21 No.7
- 발행연도
- 2007.7
- 수록면
- 1,083 - 1,089 (7page)
이용수
이 논문의 연구 히스토리 (2)
- 이 논문의 후속연구가 궁금하신가요?
- 연관 학술논문 또는 학술발표를 통해 보다 발전된 연구결과를 확인하실 수 있습니다.
- 이 논문의 연구 히스토리 확인하기
초록· 키워드
오류제보하기
This study concerns the effects of tribochemical interactions at the interface of Si-DLC (silicon-doped diamond-like carbon) film and steel ball in sliding contact on tribological properties of the film. The Si-DLC film was over-coated on pure DLC coating by radio frequency plasma-assisted chemical vapor deposition (r.f. PACVD) with different Si concentration. Friction tests against steel ball using a reciprocating type tribotester were performed in ambient environment. X-Ray photoelectron spectroscopy (XPS) and auger electron spectroscopy (AES) were used to study the chemical characteristics and elemental composition of the films and mating balls after tests. Results showed a darkgray film consisting of carbon, oxygen and silicon on the worn steel ball surface with different thickness. On the contrary, such film was not observed on the surface of the ball slid against pure DLC coating. The oxidation of Si-DLC surface and steel ball was also found at particular regions of contact area. This demonstrates that tribochemical interactions occurred at the contact area of Si-DLC and steel ball during sliding to form a tribofilm (so called transfer film) on the ball specimen. While the pure DLC coating exhibited high coefficient of friction (~0.06), the Si-DLC film showed a significant lower coefficient of friction (~0.022) with the presence of tribofilm on mating ball surface. However, the Si-DLC film possesses a very high wear rate in comparison with the pure DLC. It was found that the tribochemical interactions strongly affected tribological properties of the Si-DLC film in sliding against steel.
목차
Abstract
1. Introduction
2. Experimental details
3. Results and discussion
4. Conclusions
Acknowledgements
References
참고문헌 (16)
참고문헌 신청
Gogotsi, Yu. G., Koval’chenko, A. M. and Kossoko, I. A., 1992, “Tribochemical Interactions of Boron Carbides Against steel,” Wear, Vol. 154, pp. 133~140.
Kim, M. G., Lee, K. R. and Eun, K. Y., 1999, “Tribological Behavior of Silicon-incorporated Diamond-like Carbon Films,” Surface and Coatings Technology, Vol. 112, pp. 204~209.
Lee, K. R., Kim, M. G., Cho, S. J., Eun, K. Y. and Seong, T. Y., 1997, “Structural Dependence of Mechanical Properties of Si Incorporated Diamond-like Carbon Films Deposited by RF Plasma-assisted Chemical Vapor Deposition,” Thin Solid Films, Vol. 308~ 309
Moulder, J. F., Stickle, W. F., Spbol, P. E. and Bomben, K. D., 1995, “Handbook of X-Ray Photoelectron Spectroscopy,” Physical Electronics Inc.
Nakayama, K. and Martin, J. M., 2006, “Tribochemical Reactions at and in the Vicinity of a Sliding Contact,” Wear, Vol. 261, pp. 235~240.
Kim, M. G., Lee, K. R. and Eun, K. Y., 1999, “Tribological Behavior of Silicon-incorporated Diamond-like Carbon Films,” Surface and Coatings Technology, Vol. 112, pp. 204~209.
Lee, K. R., Kim, M. G., Cho, S. J., Eun, K. Y. and Seong, T. Y., 1997, “Structural Dependence of Mechanical Properties of Si Incorporated Diamond-like Carbon Films Deposited by RF Plasma-assisted Chemical Vapor Deposition,” Thin Solid Films, Vol. 308~ 309
Moulder, J. F., Stickle, W. F., Spbol, P. E. and Bomben, K. D., 1995, “Handbook of X-Ray Photoelectron Spectroscopy,” Physical Electronics Inc.
Nakayama, K. and Martin, J. M., 2006, “Tribochemical Reactions at and in the Vicinity of a Sliding Contact,” Wear, Vol. 261, pp. 235~240.
함께 읽어보면 좋을 논문
논문 유사도에 따라 DBpia 가 추천하는 논문입니다. 함께 보면 좋을 연관 논문을 확인해보세요!
-
Tribochemical interactions of Si-doped DLC film against steel in sliding contact
한국트라이볼로지학회 학술대회
2006 .06
-
Si 함유량에 따른 Si-DLC/DLC 코팅의 건조마찰 특성
한국생산제조학회 학술발표대회 논문집
2007 .05
-
Si 함유량에 따른 Si-DLC/DLC 코팅의 건조마찰 특성
한국생산제조학회지
2007 .12
-
Tribological properties of DLC films on polymers
한국트라이볼로지학회 학술대회
2002 .10
-
Tribolgical Characteristics of DLC Film using Substrates with Varying Hardness
KTS International Journal
2008 .12
-
Effect of Humidity on Tribological Behavior of Si-DLC/DLC Multi-layer
한국트라이볼로지학회 학술대회
2002 .10
-
Effects of bonding layer in the adhesion of DLC thin film on Al₂O₃ for an application of high temperature strength
대한기계학회 춘추학술대회
2005 .05
-
DLC 코팅된 60E1(UIC60) 강의 건조 마찰에서의 미끄럼 마찰 거동
대한기계학회 논문집 A권
2020 .02
-
실리콘 함유 DLC 박막의 마찰마모 시험에 의한 물리적 특성 및 화학적 결합 구조 변화 고찰
열처리공학회지
2011 .01
-
베어링강의 경도에 따른 DLC박막의 트라이볼로지적 특성
한국트라이볼로지학회 학술대회
2008 .11
-
Segment-structured DLC Deposition on Three-Dimensional Substrate
한국표면공학회 학술발표회 초록집
2010 .11
-
Friction and wear of DLC films in water environment
한국트라이볼로지학회 학술대회
2002 .10
-
중간층이 DLC 코팅에 미치는 영향
Corrosion Science and Technology
2011 .01
-
Hydrophobicity and Nanotribological Properties of Silicon Channels coated by Diamond-like Carbon Films
KTS International Journal
2009 .12
-
모재의 표면 거칠기가 DLC 코팅의 마멸수명에 미치는 영향
Tribology and Lubricants
2005 .06
-
베어링강의 경도변화에 따른 DLC박막특성 평가
대한기계학회 춘추학술대회
2008 .10
-
Trends of Preparation and Application of DLC Films
한국표면공학회 학술발표회 초록집
2008 .06
-
다양한 모재에 증착된 DLC 코팅의 트라이볼로지적 특성
대한기계학회 춘추학술대회
2013 .12
이 논문의 저자 정보
이 논문과 함께 이용한 논문
Atomically-thin Molecular Doping Layer for CVD Graphene Using Modified Graphene Oxide
김해나
,
김현호
,
장정인
외 4명
한국고분자학회 학술대회 연구논문 초록집
2014
.04
Plasma Electrolytic Oxidation in Surface Modification of Metals for Electronics
Mukesh Kuma
,
Sha
,
ma
외 4명
대한용접·접합학회지
2014
.06
SIMS Depth Profiling Analysis of Cl in TiCl₄ Based TiN Film by Using ClCs₂⁺ Cluster Ions
공수진
,
박상원
,
김종훈
외 4명
한국진공학회 학술발표회초록집
2012
.02
Reaction Modeling on Titanium Nitride Byproducts in CVD Trap System
Seongho Choi
,
Changhyun Pang
,
Chehoo Cho
외 1명
한국진공학회 학술발표회초록집
2008
.02
Effect of Humidity on Tribological Behavior of Si-DLC/DLC Multi-layer
J. W. YI
,
D. G. KIM
,
J. K. KIM
외 1명
한국트라이볼로지학회 학술대회
2002
.10
최근 본 자료
댓글(0)
0
UCI(KEPA) : I410-ECN-0101-2009-550-016767224