지원사업
학술연구/단체지원/교육 등 연구자 활동을 지속하도록 DBpia가 지원하고 있어요.
커뮤니티
연구자들이 자신의 연구와 전문성을 널리 알리고, 새로운 협력의 기회를 만들 수 있는 네트워킹 공간이에요.
논문 기본 정보
- 자료유형
- 학술저널
- 저자정보
- 발행연도
- 2022.6
- 수록면
- 155 - 163 (9page)
- DOI
- 10.4283/JMAG.2022.27.2.155
이용수
초록· 키워드
오류제보하기
Cerium-containing (Ce) rare earth magnets with extraordinary cost-effectiveness are widely investigated around the world. However, when the concentration of Ce is much more, the kind of these magnets exhibits very poor thermal stability and overall magnetic properties. To weaken these disadvantages, we take eutectic Y<SUB>50</SUB>Ce<SUB>50</SUB> co-substitution alloys into account in this work. Magnetic properties, microstructures and metallurgical behaviors of (Y, Ce, Nd)-Fe-B magnets are systematically researched. For (Y<SUB>50</SUB>Ce<SUB>50</SUB>)<SUB>10</SUB>Nd<SUB>20</SUB>Fe<SUB>68.9</SUB>B<SUB>1.1</SUB> SPSed permanent magnets, good overall magnetic properties are H<SUB>cj</SUB> = 725 kA/m, J<SUB>r</SUB> = 0.73 T and (BH)<SUB>max</SUB> = 81 kJ/m³. It schematically depicts that coarse grain zones and fine grain zones occur during the spark plasma sintering (SPS) process. With the Nd content increasing, the deleterious CeFe₂ phases disappear. In addition, the volume fraction and width of coarse grain zones decrease. Ce-rich and Ce-lean regions are also observed in main phases, while Y and Nd elements are uniformly distributed. TEM results show that Nd and Ce are rich in the grain boundary and Y elements prefer to enter in 2:14:1 main phases. This work is favorable to a balanced utilization of high abundance rare earth elements in Nd-Fe-B magnets.
목차
1. Introduction
2. Experimental
3. Results and Discussion
4. Conclusions
References
참고문헌 (0)
참고문헌 신청함께 읽어보면 좋을 논문
논문 유사도에 따라 DBpia 가 추천하는 논문입니다. 함께 보면 좋을 연관 논문을 확인해보세요!
-
Influence of grain boundary diffusion process on grain alignment and magnetic properties of Nd lean Nd-Fe-B hot-deformed magnets
한국자기학회 학술연구발표회 논문개요집
2021 .07
-
Manufacturing of Nd-Fe-B permanent magnets using spark plasma sintering and development of an internal grain boundary diffusion process
한국자기학회 학술연구발표회 논문개요집
2023 .05
-
Study on Microstructure and Magnetic Properties of Grain Boundary Diffusion Processed Nd-Fe-B Sintered Magnet
한국자기학회 학술연구발표회 논문개요집
2024 .05
-
Effect of post-sintering annealing conditions on the magnetic and microstructural properties of the multi-main phase Nd-Ce-Fe-B sintered magnets
한국자기학회 학술연구발표회 논문개요집
2019 .11
-
Microstructure control of Nd-rich phases in Nd-Fe-B sintered magnets
한국자기학회 학술연구발표회 논문개요집
2022 .11
-
Microstructure of Grain Boundary Diffusion Processed Nd-Fe-B Sintered Magnets : Microstructural Characteristics of HRE-rich Shells and Grain Boundary Phases
한국자기학회 학술연구발표회 논문개요집
2020 .11
-
Influence of Grain Boundary Diffusion with Cu-based Alloy on Magnetic Impurities in Nd-Ce-Fe-B Magnets
한국자기학회 학술연구발표회 논문개요집
2024 .05
-
Strategy for Enhancing Magnetic Properties in Hot-Deformed Nd-Ce-Fe-B Magnet with 50% Ce Substitution as Potential Gap Magnet
한국자기학회 학술연구발표회 논문개요집
2024 .11
-
Magnetic Properties of Ce-Fe-B magnets produced by reduction-diffusion process
한국자기학회 학술연구발표회 논문개요집
2022 .05
-
The effect of grain size, grain boundary materials, and grain boundary thickness on the magnetic properties of Fe-based magnetic materials
한국자기학회 학술연구발표회 논문개요집
2019 .11
-
Enhancement of magnetic properties of sintered Nd-Fe-B magnet with grain boundary diffusion process of Tb-Al-Cu
한국자기학회 학술연구발표회 논문개요집
2023 .05
-
Development of High Performance (L)RE-Fe-B Permanent Magnets by Grain Boundary Engineering
한국자기학회 학술연구발표회 논문개요집
2020 .07
-
Simultaneous improvement in coercivity and remanence of 60% Nd-saving (Nd,Ce,Ho)-Fe-B sintered magnets by grain boundary diffusion process with non-critical rare earth elements
한국자기학회 학술연구발표회 논문개요집
2024 .11
-
Effect of Cu addition on the magnetic and microstructural properties of multi-main phase Nd-Ce-Fe-B sintered magnet
한국자기학회 학술연구발표회 논문개요집
2021 .11
-
The grain boundary diffusion process with Nd-Cu-Zn alloy on Nd-Fe-B magnets hot deformed by Spark Plasma Sintering
한국자기학회 학술연구발표회 논문개요집
2016 .05
-
Grain Boundary Diffusion of La Based Low-melting Alloy to Nd-Fe-B Sintered Magnets
한국자기학회 학술연구발표회 논문개요집
2021 .07
-
Effect of post-sintering annealing temperature on the magnetic and microstructural properties of multi-main phase Nd-Ce-Fe-B with high Ce content
한국자기학회 학술연구발표회 논문개요집
2021 .07
-
Grain boundary diffusion sources and temperature dependent coercivity in Nd-Fe-B sintered Magnets
한국자기학회 학술연구발표회 논문개요집
2022 .05
-
Effect of Ce and La Substitution on the Microstructure and Magnetic Properties of Hot-deformed Nd-Fe-B Magnets
Journal of Magnetics
2020 .06
-
Effect of spray coating method on the magnetic properties of Nd-Fe-B sintered magnets with grain boundary diffusion
한국자기학회 학술연구발표회 논문개요집
2022 .11
이 논문의 저자 정보
최근 본 자료
댓글(0)
0